Preview

Application and Benefits of Limestone Rotary Kiln

Good Essays
Open Document
Open Document
491 Words
Grammar
Grammar
Plagiarism
Plagiarism
Writing
Writing
Score
Score
Application and Benefits of Limestone Rotary Kiln
Lime kiln is used for baking active lime and dolomite in the steel factory and ferroalloy factory. This limestone rotary kiln can produce lime with advantages of strong ability to react chemically, low volume density and large specific surface. At present, it has been one of the most preferred auxiliary equipment for steel-making, coking and calcium carbide industries.

Moreover, it is also the best kiln type in limestone industries for its strong adaptability to raw and fuel materials, convenient maintenance and low consumption benefits. As the lime rotary kiln adopts new modern technology of burner, it can make full use of cheap energy; especially utilize the most draining inflammable gas as treasure of part energy, which is harmful to the environment. Thus, it not only protects environment, but also is in line with the public policy documents on response to energy conservation, emission reduction and low carbon.

The lime quality of horizontal lime kiln production first is dependent on the amount of calcium oxide and magnesium oxide, the second is to look at birth burnt lime burning rate, and burning of birth is part of the incomplete decomposition of limestone, whereas more than burned calcined limestone. This lime activity of the part is low, it is difficult to distinguish between ordinary limestone behind production, and normal combustion temperature is 1000 ℃ 1200 ℃. Burnt-out ash is usually high combustion temperature, and time is long, the surface crack or glass shell, volume shrinkage, the color of the blackened, increase the capacity. The processing of burnt, of course, first consider the air-fuel ratio is too big or not, should be adjusted to a reasonable composition with quantity. Of course, we also must fully consider the coal quality. Also should adjust the wind to adapt it.

The features and benefits of the limestone rotary kiln areas follows:
1. Energy conservation, waste gas as the second useful source, recycling economy;
2. PLC

You May Also Find These Documents Helpful

  • Satisfactory Essays

    Lime is a commercial name for calcium oxide (CaO). When carbon dioxide (Co2) is removed from limestone, coral, seashells, or chalk they become lime. This product is easily accessible, because an abundance of limestone in found in the crust of the earth, and the Co2 is removed simply by heating the limestone. See formula below:…

    • 460 Words
    • 2 Pages
    Satisfactory Essays
  • Good Essays

    Port Kembla Steelworks has spent $18 million on upgraded sinter machines that reduce the amount of coke need for the sintering process. The sintering process being getting the small particle of iron that were too small to go through processing and putting them through 1100-1300oC heat they will coalesce and form larger particles which improves resource efficiency. The upgrade involve using natural gas rather than coke to generate the heat in the machine because natural gas has a higher heat of combustion than coke and therefore needs less to fuel the same get the same heat. This means less CO2 emissions and less fuel needed to…

    • 1475 Words
    • 6 Pages
    Good Essays
  • Powerful Essays

    manufacturers as a source of fuel to fire their energy-intensive cement kilns. Alternatively, the company…

    • 1531 Words
    • 7 Pages
    Powerful Essays
  • Powerful Essays

    There are two ways, two types of heat resistant concretes that can be prepared. Cheaper and more expensive - stronger and weaker. The first one is a high heat refractory concrete. This type will survive in real high heat and can be used in hot-face (What is hot face? Hot face is a wall facing the main heat from a source. Internal walls, floor and arches made from firebricks inside a pizza oven is hotface. Firebricks face the heat, the hot flames from wood fire and the red hot embers.) Refractory concrete can be mixed with heat resistant cement, or, can be purchased ready in bags (the packed one is most often referred to as castable.) But saying that, even though it's refractory, still it is not so straight forward to cast large hot face section/s out of it. It is different to fill holes and awkward spaces with castables. Large blocks tend to crack as a result of something called heat differences in material, or temperature differences in material in other words, which is a very powerful natural phenomena. But hey no worries Mate, we still have firebricks here luckily (firebricks those nice little fragments) for making the dome part properly (read more about heat differences in materials - basically it deals with shrinking of cooled down edges and also surfaces while middle's still hot expanded).…

    • 1931 Words
    • 8 Pages
    Powerful Essays
  • Best Essays

    AustStab Technical Note No.1 May 2002 Lime stabilisation practice 1 Introduction Lime stabilisation of materials is one of the oldest forms of stabilisation and sometimes the least understood. The stabilisation of clay subgrades using quicklime has a long and successful history in many urban and rural regions of Australia, and is cost effective and a necessary requirement for Municipalities and State Road Authorities seeking long-life roads to minimise future maintenance costs. The possible applications of lime stabilisation are to: q q q increase subgrade stiffness (see Figure 1), reduce the PI of insitu pavement material, enhance volumetric stability for the top layer of select material, q modify subbase layers to improve stiffness of the pavement, and q produce a temporary construction platform for civil works. manufactured in Australia is processed through a fluid bed, rotary or vertical shaft kilns. Problems associated with transporting lime by sea over long distances limits the importation of this binder.…

    • 4634 Words
    • 19 Pages
    Best Essays
  • Good Essays

    One of the most important of these studies was conducted by Owusu et al. where they measured pH, the pulp potential (Eh) and the dissolved oxygen content of pyrite pulp after various aeration times of the pulp. Initially, the pulp was purged with air for 3 minutes and the dissolved oxygen content was then measured with time. They observed that the dissolved oxygen concentration of the pulp reduced from 5.5 to 0.06 mg/dm3 during 5 minutes. This showed that the oxygen dissolved in the pulp was nearly completely consumed by pyrite. However with increasing aeration time, it was observed that the residual dissolved oxygen content increased to 5.21 mg/dm3. On the other hand, it was also observed that with increasing the dissolved oxygen content of the pulp, the pulp pH decreased considerably and the pulp Eh changed from a reducing to more oxidizing value. These changes in pH and Eh of the pulp were found to be favorable for the pyrite oxidation and the oxygen consumption. Therefore, Owusu et al. concluded that with increasing aeration time, the formation of the iron oxy-hydroxide species and also coating the surface with these species increase. Then, however, because of the coverage of most of the pyrite surface by these species, a significant decrease in the surface reactivity with oxygen occurs. In other words, with further increase in aeration time, the pyrite surface is…

    • 1549 Words
    • 7 Pages
    Good Essays
  • Satisfactory Essays

    Rotary kiln is composed of main drive system and auxiliary drive system, and kiln and cooler transmission system are relatively simple. Rotary kiln has two drive systems and their roles are:…

    • 366 Words
    • 2 Pages
    Satisfactory Essays
  • Better Essays

    The MgO-CaO system is remarkable for the high liquidus and solidus temperatures over the complete range 100% MgO- 100% CaO, as the eutectic for the CaO–MgO binary system occurs at 2370 ºC [3, 52]. MgO–CaO bricks are high-value refractories composed of lime (CaO) and periclase (MgO). MgO –CaO refractories has some advantageous and disadvantageous compared to MgO and CaO refractories (Table 1).…

    • 2355 Words
    • 10 Pages
    Better Essays
  • Satisfactory Essays

    Rotary kiln is a machine whose working temperature can reach the temperature to calcine superfine kaolin. At present the rotary kiln technology in our country is mature and advanced, which represents the development direction of calcination technology of superfine kaolin. However, the decomposition rate of rotary kiln is not high enough, we should impove the decomposition rate of rotary kiln. Do you know how?…

    • 385 Words
    • 2 Pages
    Satisfactory Essays
  • Powerful Essays

    Model Potash Plant Design

    • 19635 Words
    • 79 Pages

    ATTIPOE EDEM KODZO BOAKYE KWAME JUWAH CHUKWUJINDU AWELE OMENOGOR ANWULI ROSEMARY in Partial Fulfillment of the Requirements for the course Process Engineering Project April 2013. TABLE OF CONTENTS 1 CHAPTER ONE - INTRODUCTION 9 1.1 MAIN OBJECTIVE 9 1.2 SPECIFIC OBJECTIVES 9 2 CHAPTER TWO -LITERATURE REVIEW 10 2.1 PRODUCTION OF POTASSIUM CARBONATE 10 2.1.1 PRODUCTION FROM POTASSIUM CHLORIDE 10 2.1.2 PRODUCTION FROM WOOD ASH (COCOA POD ASH) 10 2.2 STORAGE AND HANDLING 11 2.3 DANGERS 11 2.4 CAUTIONS 11 2.5 USES OF POTASSIUM CARBONATE 11 2.5.1 INDUSTRIAL USES 11 2.5.2 USES IN FOOD PROCESSING 12 2.6 CHEMISTRY OF POTASSIUM CARBONATE 13 2.6.1 PHYSICALPROPERTIES 13 2.6.2 CHEMICAL PROPERTIES 13 3 CHAPTER THREE – PROCESS SELECTION AND DESCRIPTION 14 3.1 INTRODUCTION 14 3.2 LEACHER 14 3.3 CLARIFIER 15 3.4 EVAPORATOR 15 3.5 CRYSTALLIZER 16 CALCINER 16 4 CHAPTER FOUR – MATERIALAND ENERGY BALANCES 17 4.1 MATERIAL BALANCE 17 4.2 ENERGY BALANCES 23 5 CHAPTER FIVE - EQUIPMENT SPECIFICATION AND PIPING 28 5.1 PIPELINE SPECIFICATIONS 28 6 CHAPTER SIX - DESIGN OF A LEACHING VESSEL 32 6.1 PROBLEM STATEMENT 32 6.2 INTRODUCTION 32 6.3 DESCRIPTION OF EQUIPMENT 33 6.4 JUSTIFICATION 34 6.5 CHEMICAL ENGINEERING DESIGN 35 6.5.1 VISCOSITY AND DENSITY OF THE MIXTURE 35 6.5.2 DETERMINATION OF LEACHER DIMENSIONS 36 6.5.3 POWER AND SPEED OF IMPELLER REQUIRED 40 6.6 MECHANICAL ENGINEERING DESIGN 44 6.6.1 MATERIAL OF CONSTRUCTION 44 6.6.2 SHAFT DESIGN 45 6.6.3 DESIGN PRESSURE 47 6.6.4 DETERMINATION OF VESSEL THICKNESS 48 6.6.5 DEADWEIGHTAND CONTENT WEIGHT 49…

    • 19635 Words
    • 79 Pages
    Powerful Essays
  • Powerful Essays

    chromium reducing in clinker

    • 2610 Words
    • 11 Pages

    form. In the kiln, oxidizing atmosphere will play the largest role, with more oxygen in the…

    • 2610 Words
    • 11 Pages
    Powerful Essays
  • Good Essays

    Brick Kilns

    • 622 Words
    • 2 Pages

    The oldest kiln is the clamp.Invented in 4000 BCE, these are still very common in India. Clamps are temporary constructions made of green bricks or clinker. The clinker can be reused while the green bricks are sold. A slight variation is the Scove with a pile of dried bricks with tunnels at the bottom allowing heat from fires to pass through and upward in the pile of bricks. It is plastered with mud (scoved) to insulate it. Certain brick makers use permanent clamps made of refractory bricks. Two basic variations of kilns are the updraft and the downdraft kilns, named after the direction of heat movement. The updraft ones or Scotch have flues running through the floor of the kiln with spaces between the stacks of bricks to allow heat to circulate, while the top is covered for insulating the kiln. The downdraft ones are circular with the flue running from the floor to the chimney stack. The hot air is then directed downwards from the dome through the stacks of bricks.…

    • 622 Words
    • 2 Pages
    Good Essays
  • Powerful Essays

    Co-processing of wastes in cement kiln is emerging as one of the environment friendly alternative disposal method in the recent years. Distillery spent wash has high organic content and dissolved inorganic solids which require careful handling and proper disposal to avoid damage to the environment. Presently it is being used on to land to provide nutrient value, though it contaminates both the ground water and surface water sources, as most often it is practiced in non-scientific manner. The adverse effect of spent wash disposal, via bio-composting is magnified during the rainy season. Concentration of spent wash in multiple effect evaporators and its subsequent incineration is also being practiced. However, it is not found technically and economically feasible in majority of cases. Hence, Central Pollution Control Board (CPCB) proposed, co-processing of concentrated spent wash in cement kiln. There are around 400 distillery units in India, with a total production capacity of about 3800 million litres of alcohol. Average generation of spent wash is around 812 litres / litre of alcohol produced, depending on continuous or batch process and quality of molasses used etc. Thus the co-processing of spent wash concentrate in cement kiln has following benefits: (a) wastes are destroyed at a higher temperature of around 1200-1400 C and longer residence time, (b) inorganic content gets fixed with the clinker apart from using the energy content of the wastes leaving no residue behind (c) the acidic gases, if any generated during co-processing gets neutralized, since the raw material in cement kiln is alkaline in nature, and (d) such phenomenon also reduces resource requirement. While in case of incineration, residuals require to be disposed…

    • 5428 Words
    • 22 Pages
    Powerful Essays
  • Good Essays

    During fluidized bed combustion potassium and calcium from biomass ash can react with quartz (SiO2) from the bed sand already at the normal operation temperatures of 700−900 °C, forming a layer of Ca,K-silicate onto the bed particle. The layer becomes thicker in time, and the particle size increases. The layer is sticky, and the bed particles can agglomerate together increasing the bed particle size further. During unsteady operation of the boiler, or on an occasional excursion to high temperature, the whole bed can sinter. The bed agglomeration can be controlled by keeping the bed alkali contents low enough by regularly discharging the bed ash and feeding fresh sand into the bed. The chemistry of fuel ash - bed sand interactions is however complicated. It is usually useful to minimize the quartz contents in the make-up sand. The ash melting point temperatures of woody fuel ashes vary in a wide range. The wide range correlates with variations in ash composition. In general, the higher the fuel alkali and chlorine contents, the lower are the sintering and initial deformation temperatures. Wood ash starts to form agglomerates and to sinter between 900 ºC and 1000 ºC in combustion conditions. Coal and peat ashes are usually trouble free at these temperatures, even if the melting point temperatures are in the same range with biomass fuels. Coal or peat is co-fired with biomass in many multi-fuel fired boilers. The woody biomass ashes are in general much more reactive than the ashes of fossil fuels. Lower reactivity of coal and peat ashes is connected to a composition with mainly quartz and various silicate-based minerals, like aluminium silicates, calcium silicates and alkali silicates, and iron oxides. Calcium and al kali in these minerals are not in free, reactive form like they are in biomass ashes. Accordingly they are quite inert at the conditions of fluidized bed combustion. Even though combustion of woody biomass fuels is more challenging compared to coal…

    • 495 Words
    • 2 Pages
    Good Essays
  • Better Essays

    Pyrolysis has the potential of transforming used tyres into useful recyclable products. This paper demonstrates the conversion of scrap tyres into its primary products which are Pyro Oil and Carbon Black and a secondary value added compound, Activated Carbon. Further, the objectives of the work also include optimization of parameters such as temperature and feed size to study the efficiency of pyrolysis at different conditions. Three different set ups are used for pyrolysis namely the lab scale pyrolysis unit, the pilot plant scale pyrolysis unit and a conventional unit.…

    • 1258 Words
    • 6 Pages
    Better Essays

Related Topics